行業動態

90R055DD丹佛斯液壓泵安裝

2022-11-17 閱讀次數:

?丹佛斯液壓泵的安裝:丹佛斯液壓泵在安裝前應仔細檢查各部的連接是否牢固,各螺栓的緊固是否有效,各支承的密封情況是否良好,所有的連接件是否牢固丹佛斯液壓泵應注意的問題:丹佛斯液壓泵應根據產品的使用說明書進行安裝操作。

丹佛斯油缸體和安裝螺母要保持在一條直線上油缸的內外表面應保持清潔的狀態 1.固定好壓力表,調整好壓力表的額定值 用手指調整壓頭后,使其不動,再將壓力表壓回原位置壓回油缸活塞的油量,必須達到正常工作壓力下要求為5~7倍液體體積分?jǐn)?shù)。

90R055DD丹佛斯液壓泵安裝(圖1)

安裝時,應保證泵在額定壓力下的運動范圍為泵體直徑的3~4倍 2.先調好轉速,再調好油壓 調整好后,用壓力表檢查是否有壓力波動如有壓力波動,應立即停機檢查原因調整后轉速應達到額定轉速的70%~80%即可如轉速過低,油溫過高(超過75℃),應檢查原因是否與潤滑有關(如冷卻液的問題)。

泵啟動后,應觀察壓力表,如發現壓力波動,應及時調整好壓力如果壓力沒有明顯波動,但功率明顯下降(在正常情況下功率下降得越快),應考慮可能是油溫過高或潤滑不良所致 3.打開吸油泵的手動手柄,轉動壓力表手柄以顯示出壓力,調節到設定值。

打開閥門,并將液體泵回油箱由于吸油泵的吸入和出口壓差較大,需要注意液體的泄漏當液體壓力超過設定值時,必須停止泵重新啟動泵后,壓力應該不會下降到設計壓力 4.用手動鍵調好吸油泵的運行速度以確定最小流量 如果油溫較高,將泵置于高溫下運行。

在正常運行過程中,泵應保持一定的速度當吸入空氣時,油泵的出口溫度較高當吸入空氣時,將泵轉子放入出口管道內,然后將泵的出口溫度調低 5.檢查一下各個部件是否都能正常運轉 a.軸承與滑動軸承b.氣缸、活塞、缸蓋、凸輪軸、凸輪、連桿、油封等。

c.滑動軸承(包括軸套、聯軸器、泵體等);d.密封圈、密封墊、填料等;e.聯軸器、凸輪軸、滾珠絲杠、葉輪等 90L100-HF-5-AB-80-L-3-C7-E-03-GBA-42-42-24 90L100HF5AB80L3C7E03GBA424224 90-L-100-HF-5-AB-80-L-3-C7-E-03-GBA-42-42-24 90L100HF5AB80L3C7E03GBA424224 90-L-100-HF-5-AB-80-L-4-F1-E-03-GBA-38-38-24 90L100HF5AB80L4F1E03GBA383824 90L100-HF-5-AB-80-R-4-S1-F-03-GBA-35-35-24 90L100HF5AB80R4S1F03GBA353524 90-L-100-HF-5-AB-80-R-4-S1-F-03-GBA-35-35-24 90L100HF5AB80R4S1F03GBA353524 90L100-HF-5-AB-80-S-4-C7-E-03-GBA-26-26-24 90L100HF5AB80S4C7E03GBA262624 90-L-100-HF-5-AB-80-S-4-C7-E-03-GBA-26-26-24 90L100HF5AB80S4C7E03GBA262624 90L100-HF-5-AB-80-S-4-C7-F-02-GBA-30-30-20 90L100HF5AB80S4C7F02GBA303020 90-L-100-HF-5-AB-80-S-4-C7-F-02-GBA-30-30-20 90L100HF5AB80S4C7F02GBA303020 90L100-HF-5-AB-80-S-4-S1-E-03-GBA-26-26-24 90L100HF5AB80S4S1E03GBA262624 90-L-100-HF-5-AB-80-S-4-S1-E-03-GBA-26-26-24 90L100HF5AB80S4S1E03GBA262624 90L100-HF-5-AB-80-S-4-S1-F-02-GBA-30-30-20 90L100HF5AB80S4S1F02GBA303020 90-L-100-HF-5-AB-80-S-4-S1-F-02-GBA-30-30-20 90L100HF5AB80S4S1F02GBA303020 90L100-HF-5-AB-80-S-4-S1-F-03-GBA-35-35-24 90L100HF5AB80S4S1F03GBA353524 90-L-100-HF-5-AB-80-S-4-S1-F-03-GBA-35-35-24 90L100HF5AB80S4S1F03GBA353524 90L100-HF-5-AC-60-L-4-C7-F-03-GBA-35-35-24 90L100HF5AC60L4C7F03GBA353524 90-L-100-HF-5-AC-60-L-4-C7-F-03-GBA-35-35-24 90L100HF5AC60L4C7F03GBA353524 90L100-HF-5-BB-60-R-3-C7-F-03-GBA-42-42-28 90L100HF5BB60R3C7F03GBA424228 90-L-100-HF-5-BB-60-R-3-C7-F-03-GBA-42-42-28 90L100HF5BB60R3C7F03GBA424228 90L100-HF-5-BB-80-R-3-C7-E-03-GBA-42-42-24 90L100HF5BB80R3C7E03GBA424224 90-L-100-HF-5-BB-80-R-3-C7-E-03-GBA-42-42-24 90L100HF5BB80R3C7E03GBA424224 90L100-HF-5-BC-60-P-3-S1-E-00-GBA-42-42-24 90L100HF5BC60P3S1E00GBA424224 90-L-100-HF-5-BC-60-P-3-S1-E-00-GBA-42-42-24 90L100HF5BC60P3S1E00GBA424224 90L100-HF-5-BC-60-R-3-C7-F-03-GBA-42-42-28 90L100HF5BC60R3C7F03GBA424228 90-L-100-HF-5-BC-60-R-3-C7-F-03-GBA-42-42-28 90L100HF5BC60R3C7F03GBA424228 90L100-HF-5-BC-60-R-4-S1-E-03-GBA-35-35-24 90L100HF5BC60R4S1E03GBA353524 90-L-100-HF-5-BC-60-R-4-S1-E-03-GBA-35-35-24 90L100HF5BC60R4S1E03GBA353524 90L100-HF-5-BC-60-S-3-C7-D-03-GBA-32-32-24 90L100HF5BC60S3C7D03GBA323224 90-L-100-HF-5-BC-60-S-3-C7-D-03-GBA-32-32-24 90L100HF5BC60S3C7D03GBA323224 90-L-100-HF-5-BC-80-L-3-S1-E-03-GBA-30-30-24 90L100HF5BC80L3S1E03GBA303024 90-L-100-HF-5-BC-80-L-3-S1-E-03-GBA-35-35-24 90L100HF5BC80L3S1E03GBA353524 90L100-HF-5-BC-80-R-3-C7-E-03-GBA-42-42-24 90L100HF5BC80R3C7E03GBA424224 90-L-100-HF-5-BC-80-R-3-C7-E-03-GBA-42-42-24 90L100HF5BC80R3C7E03GBA424224 90-L-100-HF-5-BC-80-R-4-S1-E-03-GBA-35-35-24 90L100HF5BC80R4S1E03GBA353524 90L100-HF-5-BC-80-R-4-S1-E-03-GBA-35-35-24 90L100HF5BC80R4S1E03GBA353524 90L100-HF-5-BC-80-R-4-S1-F-03-GBA-38-38-28 90L100HF5BC80R4S1F03GBA383828 90-L-100-HF-5-BC-80-R-4-S1-F-03-GBA-38-38-28 90L100HF5BC80R4S1F03GBA383828 90L100-HF-5-BC-80-S-3-C7-E-03-GBA-35-35-24 90L100HF5BC80S3C7E03GBA353524 90-L-100-HF-5-BC-80-S-3-C7-E-03-GBA-35-35-24 90L100HF5BC80S3C7E03GBA353524 90L100-HF-5-BC-80-S-4-C7-F-02-GBA-30-30-20 90L100HF5BC80S4C7F02GBA303020 90-L-100-HF-5-BC-80-S-4-C7-F-02-GBA-30-30-20 90L100HF5BC80S4C7F02GBA303020 90L100-HF-5-BC-80-S-4-S1-E-03-GBA-17-17-20 90L100HF5BC80S4S1E03GBA171720 90-L-100-HF-5-BC-80-S-4-S1-E-03-GBA-17-17-20 90L100HF5BC80S4S1E03GBA171720 90-L-100-HF-5-CD-60-D-4-F1-L-03-GBA-35-35-28 90L100HF5CD60D4F1L03GBA353528 90L100-HF-5-CD-60-D-4-F1-L-03-GBA-35-35-28 90L100HF5CD60D4F1L03GBA353528 90L100-HF-5-CD-60-L-4-C7-F-03-GBA-35-35-24 90L100HF5CD60L4C7F03GBA353524 90-L-100-HF-5-CD-60-L-4-C7-F-03-GBA-35-35-24 90L100HF5CD60L4C7F03GBA353524 90L100-HF-5-CD-60-P-3-C7-E-00-GBA-42-42-24 90L100HF5CD60P3C7E00GBA424224 90-L-100-HF-5-CD-60-P-3-C7-E-00-GBA-42-42-24 90L100HF5CD60P3C7E00GBA424224 90-L-100-HF-5-CD-60-R-3-F1-E-03-GBA-42-42-24 90L100HF5CD60R3F1E03GBA424224 90L100-HF-5-CD-60-S-4-C7-F-03-GBA-35-35-24 90L100HF5CD60S4C7F03GBA353524 90-L-100-HF-5-CD-60-S-4-C7-F-03-GBA-35-35-24 90L100HF5CD60S4C7F03GBA353524 90-L-100-HF-5-CD-80-L-3-F1-E-03-GBA-30-30-24 90L100HF5CD80L3F1E03GBA303024 90-L-100-HF-5-CD-80-R-3-C7-E-03-GBA-26-26-24 90L100HF5CD80R3C7E03GBA262624 90L100-HF-5-CD-80-R-3-F1-E-03-GBA-35-35-24 90L100HF5CD80R3F1E03GBA353524 90-L-100-HF-5-CD-80-R-3-F1-E-03-GBA-35-35-24 90L100HF5CD80R3F1E03GBA353524 90L100-HF-5-CD-80-S-3-F1-E-03-GBA-35-35-24 90L100HF5CD80S3F1E03GBA353524 90-L-100-HF-5-CD-80-S-3-F1-E-03-GBA-35-35-24 90L100HF5CD80S3F1E03GBA353524 90L100-HF-5-CD-80-S-3-T2-E-03-GBA-42-42-24 90L100HF5CD80S3T2E03GBA424224 90-L-100-HF-5-CD-80-S-3-T2-E-03-GBA-42-42-24 90L100HF5CD80S3T2E03GBA424224 90L100-HF-5-CD-80-S-4-C7-E-03-GBA-26-26-24 90L100HF5CD80S4C7E03GBA262624 90-L-100-HF-5-CD-80-S-4-C7-E-03-GBA-26-26-24 90L100HF5CD80S4C7E03GBA262624 90L100-HF-5-CD-80-S-4-C7-F-02-GBA-30-30-20 90L100HF5CD80S4C7F02GBA303020 90-L-100-HF-5-CD-80-S-4-C7-F-02-GBA-30-30-20 90L100HF5CD80S4C7F02GBA303020 90L100-HF-5-CD-80-S-4-C7-F-03-GBA-20-26-24 90L100HF5CD80S4C7F03GBA202624 90-L-100-HF-5-CD-80-S-4-C7-F-03-GBA-20-26-24 90L100HF5CD80S4C7F03GBA202624 90L100-HF-5-CD-80-S-4-F1-E-03-GBA-17-17-20 90L100HF5CD80S4F1E03GBA171720 90-L-100-HF-5-CD-80-S-4-F1-E-03-GBA-17-17-20 90L100HF5CD80S4F1E03GBA171720 90-L-100-HF-5-NN-60-R-3-S1-E-03-GBA-42-42-24 90L100HF5NN60R3S1E03GBA424224 90L100-HF-5-NN-60-R-4-S1-E-03-GBA-35-35-24 90L100HF5NN60R4S1E03GBA353524 90-L-100-HF-5-NN-60-R-4-S1-E-03-GBA-35-35-24 90L100HF5NN60R4S1E03GBA353524 90L100-HF-5-NN-60-S-3-C7-E-02-GBA-30-30-24 90L100HF5NN60S3C7E02GBA303024 90-L-100-HF-5-NN-60-S-3-C7-E-02-GBA-30-30-24 90L100HF5NN60S3C7E02GBA303024 90L100-HF-5-NN-60-S-3-C7-E-03-GBA-32-32-24 90L100HF5NN60S3C7E03GBA323224 90-L-100-HF-5-NN-60-S-3-C7-E-03-GBA-32-32-24 90L100HF5NN60S3C7E03GBA323224 90L100-HF-5-NN-60-S-3-F1-E-03-GBA-35-35-24 90L100HF5NN60S3F1E03GBA353524 90-L-100-HF-5-NN-60-S-3-F1-E-03-GBA-35-35-24 90L100HF5NN60S3F1E03GBA353524 90-L-100-HF-5-NN-80-D-3-S1-L-03-GBA-42-42-26 90L100HF5NN80D3S1L03GBA424226 90-L-100-HF-5-NN-80-L-3-F1-E-03-GBA-38-38-24 90L100HF5NN80L3F1E03GBA383824 90-L-100-HF-5-NN-80-L-4-F1-E-03-GBA-38-38-24 90L100HF5NN80L4F1E03GBA383824 90L100-HF-5-NN-80-P-3-C7-E-03-GBA-26-26-24 90L100HF5NN80P3C7E03GBA262624 90-L-100-HF-5-NN-80-P-3-C7-E-03-GBA-26-26-24 90L100HF5NN80P3C7E03GBA262624 90L100-HF-5-NN-80-P-3-S1-E-03-GBA-40-40-24 90L100HF5NN80P3S1E03GBA404024 90-L-100-HF-5-NN-80-P-3-S1-E-03-GBA-40-40-24 90L100HF5NN80P3S1E03GBA404024 90-L-100-HF-5-NN-80-R-3-S1-E-03-GBA-26-26-24 90L100HF5NN80R3S1E03GBA262624 90-L-100-HF-5-NN-80-R-3-S1-F-03-GBA-26-26-24 90L100HF5NN80R3S1F03GBA262624 90L100-HF-5-NN-80-S-3-C6-E-03-GBA-42-42-28 90L100HF5NN80S3C6E03GBA424228 90-L-100-HF-5-NN-80-S-3-C6-E-03-GBA-42-42-28 90L100HF5NN80S3C6E03GBA424228 90L100-HF-5-NN-80-S-3-C7-F-03-GBA-42-42-24 90L100HF5NN80S3C7F03GBA424224 90-L-100-HF-5-NN-80-S-3-C7-F-03-GBA-42-42-24 90L100HF5NN80S3C7F03GBA424224 90L100-HF-5-NN-80-S-4-C6-E-04-GBA-45-45-28 90L100HF5NN80S4C6E04GBA454528 90-L-100-HF-5-NN-80-S-4-C6-E-04-GBA-45-45-28 90L100HF5NN80S4C6E04GBA454528 90L100-HF-5-NN-80-S-4-C6-F-00-GBA-17-35-24 90L100HF5NN80S4C6F00GBA173524 90-L-100-HF-5-NN-80-S-4-C6-F-00-GBA-17-35-24 90L100HF5NN80S4C6F00GBA173524 90L100-HF-5-NN-80-S-4-C6-F-03-GBA-17-35-24 90L100HF5NN80S4C6F03GBA173524 90-L-100-HF-5-NN-80-S-4-C6-F-03-GBA-17-35-24 90L100HF5NN80S4C6F03GBA173524 90L100-HF-5-NN-80-S-4-C7-E-03-GBA-21-21-24 90L100HF5NN80S4C7E03GBA212124 90-L-100-HF-5-NN-80-S-4-C7-E-03-GBA-21-21-24 90L100HF5NN80S4C7E03GBA212124 90-L-100-HF-5-NN-80-S-4-S1-E-03-GBA-35-35-24 90L100HF5NN80S4S1E03GBA353524 90L100-HF-5-NN-80-S-4-S1-F-03-GBA-35-35-24 90L100HF5NN80S4S1F03GBA353524 90-L-100-HF-5-NN-80-S-4-S1-F-03-GBA-35-35-24 90L100HF5NN80S4S1F03GBA353524 。

在線聯系
掃碼關注

微信二維碼

^返回頂部