行業動態

90L130KP柱塞泵使用前該注意什么

2022-11-21 閱讀次數:

?柱塞泵是一種可獨立完成土方挖掘、打樁、橋梁樁基、邊坡支護、水電站水工建筑物澆筑、公路工程路基壓實、隧道工程回填夯實、城市地下基礎設施施工等工程用途可在混凝土泵送主機設備中安裝使用,是工程建設中不可或缺的機械設備。

那么具體使用前該注意什么呢?下面柱塞泵廠家就給大家分享一下安裝前檢查液壓系統應保證足夠油壓、流量(工作壓力、出口壓力);油管不得被混凝土或泥漿堵塞;油箱容積不應小于規定容積,當需要超過規定容積時,應對油箱進行清洗;液壓油管應無破裂、泄漏;管路應保持通暢;在管道外接頭處應涂有黃油、機油脂等光滑油類;應使用密封元件及密封裝置;保證其良好導向性;將泵放入底座上后,應在主機上安裝定位塊并使其牢固可靠;應定期檢查管道閥門是否打開;應將管道閥門關閉并緊固;應保持管道內壓降小,避免影響混凝土泵送主機所需的進料和出料速度;液壓系統還可以經常檢查是否漏油、滲油。

90L130KP柱塞泵使用前該注意什么(圖1)

1.對于使用年限超過兩年以上的設備,應進行大修或報廢處理 如發現有裂紋、銹蝕、脫落等現象,應及時更換換管應在停機后進行操作前應檢查各連接處有無松動,有無滲漏現象,并嚴格按照操作規程進行操作管路一般都有密封圈,不要輕易擰緊或者更換。

清洗液壓油時,如發現有泄露現象,要在油池內放一段時間再清洗干凈 2.對混凝土泵,應進行清洗、養護,保證其性能良好 在施工中,使用泵時應確保管道暢通,管道內不得有水、沙粒等異物進入管道內管道外接頭處應涂有黃油、機油脂等光滑油類或應使用密封元件及密封裝置等。

當需要超過規定容積時,將管道閥門關閉并緊固需清洗泵時須用水沖洗干凈后,再加入肥皂水清洗表面,不得使用熱水及其他腐蝕性液體混凝土泵在運行一段時間后,待其各項性能良好后,可進行適當放松,進行空載運轉一段時間后才可進行作業。

90-L-130-KP-5-DE-80-L-3-F1-H-03-GBA-35-35-24 90L130KP5DE80L3F1H03GBA353524 90L130-KP-5-DE-80-L-3-F1-H-05-GBA-45-45-24 90L130KP5DE80L3F1H05GBA454524 90-L-130-KP-5-DE-80-L-3-F1-H-05-GBA-45-45-24 90L130KP5DE80L3F1H05GBA454524 90L130-KP-5-DE-80-P-3-C8-F-03-GBA-35-35-24 90L130KP5DE80P3C8F03GBA353524 90-L-130-KP-5-DE-80-P-3-C8-F-03-GBA-35-35-24 90L130KP5DE80P3C8F03GBA353524 90L130-KP-5-DE-80-R-3-C8-H-03-GBA-38-38-30 90L130KP5DE80R3C8H03GBA383830 90-L-130-KP-5-DE-80-R-3-C8-H-03-GBA-38-38-30 90L130KP5DE80R3C8H03GBA383830 90L130-KP-5-DE-80-R-3-C8-H-06-GBA-38-38-30 90L130KP5DE80R3C8H06GBA383830 90-L-130-KP-5-DE-80-R-3-C8-H-06-GBA-38-38-30 90L130KP5DE80R3C8H06GBA383830 90L130-KP-5-DE-80-R-4-C8-H-03-EBA-42-42-30 90L130KP5DE80R4C8H03EBA424230 90-L-130-KP-5-DE-80-R-4-C8-H-03-EBA-42-42-30 90L130KP5DE80R4C8H03EBA424230 90L130-KP-5-DE-80-R-4-C8-H-03-EBA-42-42-30-F055 90L130KP5DE80R4C8H03EBA424230F055 90-L-130-KP-5-DE-80-R-4-C8-H-03-EBA-42-42-30-F055 90L130KP5DE80R4C8H03EBA424230F055 90L130-KP-5-DE-80-R-4-C8-H-03-GBA-36-36-30 90L130KP5DE80R4C8H03GBA363630 90-L-130-KP-5-DE-80-R-4-C8-H-03-GBA-36-36-30 90L130KP5DE80R4C8H03GBA363630 90L130-KP-5-DE-80-R-4-C8-H-03-GBA-36-36-30-F055 90L130KP5DE80R4C8H03GBA363630F055 90-L-130-KP-5-DE-80-R-4-C8-H-03-GBA-36-36-30-F055 90L130KP5DE80R4C8H03GBA363630F055 90L130-KP-5-NN-80-L-3-F1-F-03-GBA-26-26-24 90L130KP5NN80L3F1F03GBA262624 90-L-130-KP-5-NN-80-L-3-F1-F-03-GBA-26-26-24 90L130KP5NN80L3F1F03GBA262624 90L130-KP-5-NN-80-L-3-F1-F-03-GBA-38-38-24 90L130KP5NN80L3F1F03GBA383824 90-L-130-KP-5-NN-80-L-3-F1-F-03-GBA-38-38-24 90L130KP5NN80L3F1F03GBA383824 90L130-KP-5-NN-80-L-3-F1-F-06-GBA-38-38-24 90L130KP5NN80L3F1F06GBA383824 90-L-130-KP-5-NN-80-L-3-F1-F-06-GBA-38-38-24 90L130KP5NN80L3F1F06GBA383824 90L130-KP-5-NN-80-L-3-F1-H-03-GBA-38-38-24 90L130KP5NN80L3F1H03GBA383824 90-L-130-KP-5-NN-80-L-3-F1-H-03-GBA-38-38-24 90L130KP5NN80L3F1H03GBA383824 90L130-KP-5-NN-80-L-3-F1-H-03-GBA-42-42-24 90L130KP5NN80L3F1H03GBA424224 90-L-130-KP-5-NN-80-L-3-F1-H-03-GBA-42-42-24 90L130KP5NN80L3F1H03GBA424224 90L130-KP-5-NN-80-L-4-F1-H-03-GBA-35-35-24 90L130KP5NN80L4F1H03GBA353524 90-L-130-KP-5-NN-80-L-4-F1-H-03-GBA-35-35-24 90L130KP5NN80L4F1H03GBA353524 90L130-KP-5-NN-80-P-3-F1-F-04-GBA-40-40-24 90L130KP5NN80P3F1F04GBA404024 90-L-130-KP-5-NN-80-P-3-F1-F-04-GBA-40-40-24 90L130KP5NN80P3F1F04GBA404024 90L130-KP-5-NN-80-P-3-F1-F-05-GBA-40-40-24 90L130KP5NN80P3F1F05GBA404024 90-L-130-KP-5-NN-80-P-3-F1-F-05-GBA-40-40-24 90L130KP5NN80P3F1F05GBA404024 90L130-KP-5-NN-80-P-3-F1-H-03-GBA-42-42-24 90L130KP5NN80P3F1H03GBA424224 90-L-130-KP-5-NN-80-P-3-F1-H-03-GBA-42-42-24 90L130KP5NN80P3F1H03GBA424224 90L130-KP-5-NN-80-P-4-F1-H-03-GBA-26-26-24 90L130KP5NN80P4F1H03GBA262624 90-L-130-KP-5-NN-80-P-4-F1-H-03-GBA-26-26-24 90L130KP5NN80P4F1H03GBA262624 90L130-KP-5-NN-80-P-4-F1-H-03-GBA-35-35-24 90L130KP5NN80P4F1H03GBA353524 90-L-130-KP-5-NN-80-P-4-F1-H-03-GBA-35-35-24 90L130KP5NN80P4F1H03GBA353524 90L130-KP-5-NN-80-P-4-F1-H-03-GBA-38-38-24 90L130KP5NN80P4F1H03GBA383824 90-L-130-KP-5-NN-80-P-4-F1-H-03-GBA-38-38-24 90L130KP5NN80P4F1H03GBA383824 90L130-KP-5-NN-80-R-3-F1-F-03-GBA-35-35-24 90L130KP5NN80R3F1F03GBA353524 90-L-130-KP-5-NN-80-R-3-F1-F-03-GBA-35-35-24 90L130KP5NN80R3F1F03GBA353524 90L130-KP-5-NN-80-R-3-F1-F-03-GBA-35-35-30 90L130KP5NN80R3F1F03GBA353530 90-L-130-KP-5-NN-80-R-3-F1-F-03-GBA-35-35-30 90L130KP5NN80R3F1F03GBA353530 90L130-KP-5-NN-80-R-3-F1-F-06-GBA-35-35-30 90L130KP5NN80R3F1F06GBA353530 90-L-130-KP-5-NN-80-R-3-F1-F-06-GBA-35-35-30 90L130KP5NN80R3F1F06GBA353530 90L130-KP-5-NN-80-R-3-F1-H-00-GBA-35-35-24 90L130KP5NN80R3F1H00GBA353524 90-L-130-KP-5-NN-80-R-3-F1-H-00-GBA-35-35-24 90L130KP5NN80R3F1H00GBA353524 90L130-KP-5-NN-80-R-3-F1-H-00-GBA-42-42-24 90L130KP5NN80R3F1H00GBA424224 90-L-130-KP-5-NN-80-R-3-F1-H-00-GBA-42-42-24 90L130KP5NN80R3F1H00GBA424224 90L130-KP-5-NN-80-R-3-F1-H-03-EBA-35-35-30 90L130KP5NN80R3F1H03EBA353530 90-L-130-KP-5-NN-80-R-3-F1-H-03-EBA-35-35-30 90L130KP5NN80R3F1H03EBA353530 90L130-KP-5-NN-80-R-3-F1-H-03-GBA-35-35-24 90L130KP5NN80R3F1H03GBA353524 90-L-130-KP-5-NN-80-R-3-F1-H-03-GBA-35-35-24 90L130KP5NN80R3F1H03GBA353524 90L130-KP-5-NN-80-R-3-F1-H-03-GBA-35-35-30 90L130KP5NN80R3F1H03GBA353530 90-L-130-KP-5-NN-80-R-3-F1-H-03-GBA-35-35-30 90L130KP5NN80R3F1H03GBA353530 90L130-KP-5-NN-80-R-4-F1-F-03-GBA-35-35-24 90L130KP5NN80R4F1F03GBA353524 90-L-130-KP-5-NN-80-R-4-F1-F-03-GBA-35-35-24 90L130KP5NN80R4F1F03GBA353524 90L130-KP-5-NN-80-R-4-F1-F-03-GBA-36-36-24 90L130KP5NN80R4F1F03GBA363624 90L130-KP-5-NN-80-R-4-F1-H-03-GBA-32-32-24 90L130KP5NN80R4F1H03GBA323224 90-L-130-KP-5-NN-80-R-4-F1-H-03-GBA-32-32-24 90L130KP5NN80R4F1H03GBA323224 90L130-KP-5-NN-80-R-4-F1-H-03-GBA-35-14-24 90L130KP5NN80R4F1H03GBA351424 90-L-130-KP-5-NN-80-R-4-F1-H-03-GBA-35-14-24 90L130KP5NN80R4F1H03GBA351424 90L130-KP-5-NN-80-R-4-F1-H-03-GBA-42-42-24 90L130KP5NN80R4F1H03GBA424224 90-L-130-KP-5-NN-80-R-4-F1-H-03-GBA-42-42-24 90L130KP5NN80R4F1H03GBA424224 90L130-KP-5-NN-80-S-3-C8-F-03-GBA-35-35-24 90L130KP5NN80S3C8F03GBA353524 90-L-130-KP-5-NN-80-S-3-C8-F-03-GBA-35-35-24 90L130KP5NN80S3C8F03GBA353524 90L130-KP-5-NN-80-S-3-F1-F-03-EBA-35-35-24 90L130KP5NN80S3F1F03EBA353524 90-L-130-KP-5-NN-80-S-3-F1-F-03-EBA-35-35-24 90L130KP5NN80S3F1F03EBA353524 90L130-KP-5-NN-80-S-3-F1-F-03-GBA-26-26-24 90L130KP5NN80S3F1F03GBA262624 90-L-130-KP-5-NN-80-S-3-F1-F-03-GBA-26-26-24 90L130KP5NN80S3F1F03GBA262624 90L130-KP-5-NN-80-S-3-F1-F-03-GBA-35-35-24 90L130KP5NN80S3F1F03GBA353524 90-L-130-KP-5-NN-80-S-3-F1-F-03-GBA-35-35-24 90L130KP5NN80S3F1F03GBA353524 90L130-KP-5-NN-80-S-4-F1-F-03-GBA-35-35-24 90L130KP5NN80S4F1F03GBA353524 90-L-130-KP-5-NN-80-S-4-F1-F-03-GBA-35-35-24 90L130KP5NN80S4F1F03GBA353524 90L130-KP-5-NN-80-S-4-F1-F-04-GBA-42-42-24 90L130KP5NN80S4F1F04GBA424224 90-L-130-KP-5-NN-80-S-4-F1-F-04-GBA-42-42-24 90L130KP5NN80S4F1F04GBA424224 90L130-KP-5-NN-80-S-4-F1-H-02-GBA-14-35-24 90L130KP5NN80S4F1H02GBA143524 90-L-130-KP-5-NN-80-S-4-F1-H-02-GBA-14-35-24 90L130KP5NN80S4F1H02GBA143524。

在線聯系
掃碼關注

微信二維碼

^返回頂部